Dave: Here's what the fuel pump looks like: http://store.brownspoint.com/df4/fig009.asp I buy parts from Browns Point in NJ, because they have all the parts drawings on their website. Here's what I bought for my 2004 model: #65720-986B0 Fuel Connector $18.57 #65750-87J11 Fuel Hose Connector $15.50 #09103-06237 Bolt $ 2.07 See the drawing below: http://store.brownspoint.com/df4/fig031.asp I already had a 3 gallon tank and hose assembly from a previous boat. I have limited experience with this setup, as I just got my M-17 launched last fall. I found that the system is somewhat unusually slow to prime. I started the motor at the ramp, motored about 100 yards and it quit. So I had to sail into my slip! Anyhow, when it gets well-primed it works with no problem. I ran it 45 minutes in a garbage can in my drive, and up to 30 minutes at a time on the lake I replaced the water pump, and solved gear shifting problems during the winter, so need to run it again in the drive. Maybe tomorrow. If so, I'll send you photos. Mark House ----- Original Message ----- From: "W David Scobie" <wdscobie@yahoo.com> To: "For and about Montgomery Sailboats" <montgomery_boats@mailman.xmission.com> Sent: Friday, March 04, 2011 3:51 PM Subject: Re: M_Boats: M 15 outboard and filling the fuel tank mark: what parts did you order? i've looked into this to 'retrofit' my suzuki 4HP and i always run into a 'wall' of information that says i need about 12 part ... one of which is the 6HP's fuel pump. :: Dave Scobie :: M17 #375 - SWEET PEA - www.m17-375.webs.com :: Sage Marine - www.sagemarine.us --- On Fri, 3/4/11, Mark House <itsmark@bresnan.net> wrote: I noticed that My 4 HP Suzuki has a fuel pump that pumps gas from the integral tank to the carb. So I threw away the tank and added a gas line fitting. Got parts supposed to go on the 6HP. It works fine from a remote 3 gallon tank. Maybe some other small motors have a similar arrangement. Biggest problem was how to plug the hole in the cowling where the tank fill used to stick out! Mark House _______________________________________________ http://mailman.xmission.com/cgi-bin/mailman/listinfo/montgomery_boats When posting, remember that there is no privacy on the Internet!